Journal of Food Quality and Hazards Control

en Rheological Quality Control Tests of Commercial Strawberry Stirred Yogurt: Pseudo-chewing Process تخصصي Special Original article Original article <pre style="text-align:justify"> Background: The rheological behavior of yogurt plays a crucial role in determining the quality of the product. This study aimed to develop a rheological quality control test replicating pseudo-chewing using experimental rheological protocols.</pre> <pre style="text-align:justify"> Methods: The strawberry stirred yogurt sample was produced, in a 90 g pot, and commercialized in April 2023 by SOUMMAM dairy products, Bejaia, Akbou, Algeria. Rheological properties of a 0.6 ml yogurt sample were evaluated for each test measurement using a rheometer with a cone/plate geometry at a constant temperature of 25±0.1 °C. The shear flow experimental protocol involved three steps: a shear rate ramp, followed by a plateau at the maximum shear rate for 15 min, and afterward the ramp was reversed to measure the downward flow curve. The viscoelastic properties were evaluated by two experimental protocols in the Linear Viscoelastic Region. These properties were studied under oscillatory frequencies (0.1-100 Hz) with and without pre-shearing at 400 1/s for 15 min to simulate the pseudo-chewing process. All experimental data were analyzed and fitted using MS Excel and MS Excel Solver.</pre> <pre style="text-align:justify"> Results: The stirred yogurt samples showed a non-Newtonian viscoelastic flow behavior with thixotropy. Both upward and downward shear rate flow curves of the sample exhibited shear-thinning behavior described by the Herschel-Bulkley model with high regression coefficient of R2=0.98 and 0.99, respectively. Dynamic measurements showed that pseudo-chewing causes considerable changes in rheological parameters such as complex modulus, complex viscosity, and loss tangent. The pre-shearing altered complex modulus and complex viscosity, corresponding to an alteration in the yogurt’s firmness and flow properties.</pre> Conclusions: The rheological procedures suggested in the present study can be used as rheological quality control tests of commercial strawberry stirred yogurt. This procedure can successfully simulate pseudo-chewing by offering information on the flow and viscoelastic characteristics of yogurt in the mouth during mastication. DOI: 10.18502/jfqhc.11.4.17440 Rheology, Quality Control, Yogurt, Mastication 223 231 http://jfqhc.ssu.ac.ir/browse.php?a_code=A-10-1774-1&slc_lang=en&sid=1 G. Benchabane 0009-0005-0875-7125 No Laboratoire de Génie Energétique et Matériaux, LGEM, Université de Biskra, B.P. 145, 07000 Biskra, Algeria A. Benchabane No Laboratoire de Génie Energétique et Matériaux, LGEM, Université de Biskra, B.P. 145, 07000 Biskra, Algeria A. Benslimane abdelhakim.benslimane@univ-bejaia.dz 0000-0002-6554-6309 Yes Laboratoire de Mécanique, Matériaux et Energétique (L2ME), Université de Bejaia, Targa Ouzemmour, 06000 Bejaïa, Algeria K. Lamamra No Plateau Technique d'Analyse Physico-Chimiques -Biskra-CRAPC, El Hadjeb, Biskra, Algeria M. Yagoub No Hydraulic Development and Environment Laboratory, University of Biskra, 07000, Biskra, Algeria I.M. Mahbubul No Institute of Energy Engineering, Dhaka University of Engineering & Technology, Gazipur 1707, Bangladesh K. Bekkour No ICube Mechanical Department, CNRS/University of Strasbourg, 67000 Strasbourg, France